关闭
 
读者在线:用户名 密码
首页 期刊简介 投稿须知 期刊目录 专家风采 编委会 特邀顾问 联系我们 移动出版
  1. 1
  2. 2
  3. 3
  4. 4
  5. 5



刊物信息

期刊名称:药物分析杂志
主管单位:中国科学技术协会
主办单位:中国药学会
承办:中国食品药品检定研究院
主编:金少鸿
地址:北京天坛西里2号
邮政编码:100050
电话:010-67012819,67058427
电子邮箱:ywfx@nicpbp.org.cn
国际标准刊号:ISSN 0254-1793
国内统一刊号:CN 11-2224/R
邮发代号:2-237
 

访问统计
您是第  4 7 4 5 2 4 2 位浏览者
您当前的位置:首页 >> 正文

中性硼硅玻璃安瓿中铝、硅、硼元素的迁移量与其内表面脱片趋势关系的研究

Study on the relationship between the migration of aluminum, silicon and boron in neutral borosilicate glass ampules and the tendency of the inner surface stripping

作者(英文):
分类号:R917
出版年·卷·期(页码):2019,39 (12):2214-2220
DOI: 10.16155/j.0254-1793.2017.01.01
-----摘要:-------------------------------------------------------------------------------------------

目的:考察中性硼硅玻璃安瓿中铝(Al)、硅(Si)、硼(B)元素的迁移量与内表面脱片趋势的关系。方法:采用亚甲基蓝染色及扫描电子显微镜(scanning electron microscope,SEM)法观察中性硼硅玻璃安瓿被侵蚀液侵蚀后的脱片情况,并通过电感耦合等离子体发射光谱(inductively coupled plasma optical emission spectrometer,ICP-OES)法测定不同侵蚀时间的中性硼硅玻璃安瓿中Al、Si、B元素的迁移量,根据迁移量的变化及脱片的趋势确定二者之间的关系。结果:电感耦合等离子体发射光谱法测定的3种元素质量浓度在0.2~10.0 mg·L-1范围内线性关系良好,相关系数为0.999 4~0.999 9;回收率为88.2%~100.5%;3种元素检测下限分别为0.001 5 μg·mL-1(Al)、0.002 9 μg·mL-1(Si)、0.020 5 μg·mL-1(B)。随着时间增加,Al、Si、B的迁移量不断增大,对应时间点的脱片情况也不断加剧,二者呈同向变化关系。结论:可通过ICP-OES检测药物溶液中Al、Si、B的含量来推断包装液体药物的中性硼硅玻璃安瓿内表面的脱片情况。

-----英文摘要:---------------------------------------------------------------------------------------

Objective: To investigate the relationship between the migration of aluminum (Al),silicon (Si) and boron (B) in the neutral borosilicate glass ampoule and the tendency of the inner surface stripping. Methods: Methylene blue staining and scanning electron microscopy (SEM) were used to observe the epitaxial condition of neutral borosilicate glass ampoules eroded by erosive liquid,and inductively coupled plasma optical emission spectrometer (ICP-OES) was used to determine migration of Al,Si and B in neutral borosilicate glass ampoules with different erosion times. The relationship between the epitaxial condition and the leaching amount is determined by the change in migration and the trend of stripping. Results: The linear concentration of each element in the range of 0.2-10.0 mg·L-1 was good,the correlation coefficient was 0.999 4-0.999 9;The recovery rate was 88.2%-100.5%;The detection limits of the three elements were 0.001 5 μg·mL-1 (Al),0.002 9 μg·mL-1 (Si),0.020 5 μg·mL-1 (B). As time goes on,the migration of Al,Si and B is increasing,and the stripping situation at corresponding time points is also intensified. The migration of three elements was positively correlated with the inner surface stripping. Conclusion: The content of Al,Si,and B in the drug solution can be detected by ICP-OES to infer the release of the neutral borosilicate glass ampoule of the packaged liquid drug.

-----参考文献:---------------------------------------------------------------------------------------

[1] 潘云雪,陈成飞,金朦娜,等.ICP-MS测定明胶空心胶囊中铅、铬、镉、砷、铜的含量[J].中国现代应用药学,2014,31(3):339 PAN YX,CHEN CF,JIN MN,et al. Determination of Pb,Cr,Cd,As and Cu in vacant gelatin capsules by ICP-MS[J].Chin J Mod Appl Pharm,2014,31(3):339
[2] 周健丘,梅丹.药品包装材料与药品质量和安全性的影响[J].药物不良反应杂志,2011,13(1):27 ZHOU JQ,MEI D.Influence of pharmaceutical packaging materials on quality and safety of medicines[J].Adv Drug React J,2011,13(1):27
[3] 梁叶,袁春梅.药用玻璃包装材料是保证药品质量的重要因素[J].轻工标准与质量,2007(5):23 LIANG Y,YUAN CM.Pharmaceutical glass packaging materials are important factors in ensuring the quality of medicines[J].Light Ind Stand Qual,2007(5):23
[4] 国家标准化组织.正常大规模生产合成的玻璃成分分类指南及其试验方法[S].1997 International Organization for Standardization.Guidelines on Types of Glass of Normal Bulk-production Composition and Their Test Methods[S].1997
[5] 国家食品药品监督管理局药品审评中心.化学药品注射剂与药用玻璃包装容器相容性研究技术指导原则(征求意见稿)[S].2013 State Food and Drug Administration Drug Evaluation Center.Technical Guidelines for the Study of Chemical Injections and Pharmaceutical Glass Packaging Containers(Consultation draft)[S].2013
[6] 国家食品药品监督管理总局.关于发布化学药品注射剂与药用玻璃包装容器相容性研究技术指导原则(试行)的通告[S].2015 State Food and Drug Administration.Notice on the Technical Guidelines for the Release of the Compatibility of Chemical Injections and Pharmaceutical Glass Packaging Containers(Trial).2015
[7] MORANDOTTI A,SWIFT R.Nexa注射器-苛刻产品的最佳选择[J].医药包装,2015,38(2):38 MORANDOTTI A,SWIFT R.Nexa syringe-The best choice for demanding products[J].Pharm Packag,2015,38(2):38
[8] 张广湘,林杨,陈晓媛,等.预灌封注射器玻璃针管内表面化学稳定性研究[J].临床医学工程,2016,23(3):270 ZHANG GX,LIN Y,CHEN XY,et al.Study on chemical stability of inner surface of prefilled syringe glass needle[J].Clin Med Eng,2016,23(3):270
[9] 李烨,张毅兰.通过加速试验考察不同介质对药用玻璃容器形成脱片的影响[J].中国医药工业杂志,2015,46(3):293 LI Y,ZHANG YL.Investigate the effect of different media on the formation of medicinal glass containers by Accelerated Test[J].Chin J Pharm,2015,46(3):293
[10] 国家食品药品监督管理总局.化学药品注射剂与药用玻璃包装容器相容性研究技术指导原则[S].2015 State Food and Drug Administration.Technical Guidelines on Research of Chemical Injection and Pharmaceutical Glass Packaging Container Compatibility[S].2015
[11] 潘叙恩,张译方,张春华,等.丙泊酚注射液与中性硼硅玻璃安瓿包材相容性研究[J].中国测试,2017,43(5):45 PAN XE,ZHANG ZF,ZHANG CH,et al. Evaluating compatibility between propofol injection and neutral borosilicate glass ampoule[J].China Meas Test,2017,43(5):45
[12] USP 40-NF 35[S].2017:1660
[13] 国家药品监督管理局.国家药用包装容器(材料)标准(试行)[S].2002:122 State Drug Administration.National Pharmaceutical Packaging Container(Material)Standard(Trial)[S].2002:122
[14] 中华人民共和国药典2015年版.四部[S].2015:375 ChP 2015.Vol Ⅳ[S].2015:375
[15] 吴永坤,龚方红,沙德仁.纤维玻璃耐碱性的研究[J].玻璃纤维,2004(4):6 WU YK,GONG FH,SHA DR.Study on alkali resistance of fiber glass[J].Fiber Glass,2004(4):6

欢迎阅读《药物分析杂志》!您是该文第 45位读者!

药物分析杂志 © 2009
地址:北京天坛西里2号 邮政编码:100050; 电子邮件:ywfx@nicpbp.org.cn

本系统由北京博思汇文数字科技有限公司设计开发 技术服务电话:13520358590